Home > Scale Inhibitor
Safety Data Sheet
Issue Date: 12/04/2022 Print Date: 12/04/2022 Initial Date: 12/04/2022 V.0229.13.01
Product Identifier
|
Product name |
Scale Inhibitor |
|
Product model |
RT7-17 |
|
Synonyms |
|
|
Other means of identification |
Not Available |
Relevant identified uses of the substance or mixture and uses advised against
|
Relevant identified uses |
Reduce the corrosion rate, prevent the formation of scale. |
|
Uses advised against |
Industrial use only. |
Details of the supplier of the safety data sheet
|
Registered company name |
Tianjin RealTech International Co., Ltd |
|
Address |
Baoneng Building Suite B504, Hongqiao, Tianjin, China |
|
Telephone |
(86) 186 5376 7086 |
|
|
Emergency telephone number
|
Association/Organization |
Tianjin RealTech International Co., Ltd |
|
Emergency telephone numbers |
(86)156 8932 3262 |
Hazard classification according to GHS
|
Acute Toxicity – Oral |
Category 4 |
|
Serious Eye Damage/Irritation |
Category 2A |
Label elements
|
Hazard pictograms |
|
|
Signal Word |
Warning |
Hazard statement(s)
|
H302 |
Harmful if swallowed |
|
H320 |
Causes eye damage irritation |
Precautionary statement(s)
|
Prevention |
P210 |
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. |
|
P264 |
Wash thoroughly after handling. |
|
|
P270 |
Do not eat, drink or smoke when using this product. |
|
|
P280 |
Wear protective gloves/protective clothing/eye protection/face protection. |
|
|
Storage |
P403 |
Store in a well-ventilated place. |
|
Disposal |
P501 |
Dispose of contents/container in accordance with local / regional / national / international regulations. |
Hazard description- Physical and chemical hazards
|
Physical and chemical hazards |
Combustible liquids in case of flame and high fever. |
Hazard description- Health hazards
|
Inhaled |
Inhalation of the product may produce adverse health effects or irritation of the respiratory tract following discomfort. |
|
Ingestion |
Accidental ingestion of the product may be harmful. |
|
Skin Contact |
Entry into the blood-stream, though, for example, cuts, abrasions or lesions, may produce systemic injury with harmful effects. |
|
Eye |
This product may cause temporary discomfort following direct contact with the eye. |
Hazard description- Environmental hazards
|
|
Please refer to 12th chapter of SDS. |
|
Component |
Cas No. |
EC No. |
Concentration (weight percent, %) |
|
ATMP |
6419-19-8 |
229-146-5 |
18~22 |
|
Water |
7732-18-5 |
231-791-2 |
63~72 |
|
EDTMPS |
22036-77-7 |
244-742-5 |
10~15 |
Description of first aid measures
|
General advice |
Immediate medical attention is required. Show this safety data sheet (SDS) to the doctor in attendance. |
|
Eye contact |
Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician if feel uncomfortable. |
|
Skin contact |
Take off contaminated clothing and shoes immediately. Wash off with plenty of water for at least 15 minutes and consult a physician if feel uncomfortable. |
|
Ingestion |
Do not induce vomiting. Never give anything by mouth to an unconscious person. Call a physician or Poison Control Center immediately. |
|
Inhalation |
Move victim into fresh air. If breathing is difficult, give oxygen. Do not use mouth to mouth resuscitation if victim ingested or inhaled the substance. If not breathing, give artificial respiration and consult a physician immediately. |
|
Protecting of first-aiders |
Ensure that medical personnel are aware of the substance involved. Take precautions to protect themselves and prevent spread of contamination. |
Most important symptoms and effects, both acute and delayed
|
1 |
Substance accumulation, in the human body, may occur and may cause some concern following repeated or long-term occupational exposure. |
Indication of any immediate medical attention and special treatment needed
|
1 |
Treat symptomatically. |
|
2 |
Symptoms may be delayed. |
Extinguishing media
|
Suitable extinguishing media |
Dry chemical, carbon dioxide or alcohol-resistant foam. |
|
Unsuitable extinguishing media |
Do not use a solid water stream. |
Specific hazards arising from the substance or mixture
|
1 |
Fire may produce irritating, poisonous or corrosive gases. |
|
2 |
Development of hazardous combustion gases or vapor possible in the event of fire. |
|
3 |
May expansion or decompose explosively when heated or involved in fire. |
Advice for firefighters
|
1 |
As in any fire, wear self-contained breathing apparatus (MSHA/NIOSH approved or equivalent) and full protective gear. |
|
2 |
Fight fire from a safe distance, with adequate cover. |
|
3 |
Prevent fire extinguishing water from contaminating surface water or the ground water system. |
Personal precautions, protective equipment and emergency procedures
|
1 |
Fully encapsulating, vapor protective clothing should be worn for spills and leaks with no fire. |
|
2 |
Do not touch or walk through spilled material. |
|
3 |
Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. |
|
4 |
Use personal protective equipment, do not breathe gas/mist/vapour/spray. |
|
5 |
Ensure adequate ventilation. Remove all sources of ignition. Take precautionary measures against static discharges. |
|
6 |
Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. |
Environmental precautions
|
1 |
Prevent further leakage or spillage if safe to do so. |
|
2 |
Discharge into the environment must be avoided. |
Methods and materials for containment and cleaning up
|
1 |
Absorb spilled material in dry sand or inert absorbent. In case of large amount of spillage, contain a spill by bunding. |
|
2 |
Adhered or collected material should be promptly disposed of, in accordance with appropriate laws and regulations. |
|
3 |
Remove all sources of ignition. Use spark-proof tools and explosion-proof equipment. |
Precautions for safe handling
|
1 |
Handling is performed in a well-ventilated place. |
|
2 |
Wear suitable protective equipment. |
|
3 |
Avoid contact with skin and eyes. |
|
4 |
Keep away from heat/sparks/open flames/ hot surfaces. |
Precautions for storage
|
1 |
Keep containers tightly closed. |
|
2 |
Keep containers in a dry, cool and well-ventilated place. |
|
3 |
Keep away from heat/sparks/open flames/hot surfaces. |
|
4 |
Containers which are opened must be carefully resealed and kept upright to prevent leakage. |
Control parameters
|
Occupational Exposure limit values |
No information available |
|
Biological limit values |
No information available |
|
Monitoring methods |
|
Engineering controls
|
1 |
Ensure adequate ventilation, especially in confined areas. |
|
2 |
Ensure that eyewash stations and safety showers are close to the workstation location. |
|
3 |
Use explosion-proof electrical/ventilating/lighting/equipment. |
|
4 |
Set up emergency exit and necessary risk-elimination area. |
Personal protection equipment
|
General requirement |
|
|
|
|
|
|
|
Eye protection |
Tightly fitting safety goggles (approved by EN 166(EU) or NIOSH (US). |
|||||
|
Hand protection |
Wear protective gloves（such as butyl rubber）, passing the tests according to EN 374(EU), US F739 or AS/NZS 2161.1 standard. |
|||||
|
Respiratory protection |
If exposure limits are exceeded or if irritation or other symptoms are experienced, use a full-face respirator with multi-purpose combination (US) or type AXBEK (EN 14387) respirator cartridges. |
|||||
|
Skin and body protection |
Wear fire/flame resistant/retardant clothing and antistatic boots. |
|||||
SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
Information on basic physical and chemical properties
|
Appearance |
Colorless to yellow liquid |
Odour |
No special odor |
|
Physical state |
Liquid |
Odour threshold |
No data available |
|
Relative density (Water =1) |
1.05~1.25 (60℃) |
Partition coefficient n- octanol / water |
No data available |
|
pH (as supplied) |
2-5 |
Auto-ignition temperature (°C) |
No data available |
|
Freezing point(℃) |
No data available |
Decomposition temperature |
No data available |
|
Initial boiling point and boiling range (°C) |
>35 |
Kinematic viscosity |
No data available |
|
Flash point (closed cup, °C) |
>93 |
Molecular weight (g/mol) |
No data available |
|
Evaporation rate |
No data available |
Particle characteristics |
Not applicable |
|
Flammability |
No data available |
Explosive properties |
No data available |
|
Upper Explosive Limit (%) |
No data available |
Oxidising properties |
No data available |
|
Lower Explosive Limit (%) |
No data available |
Surface Tension (dyn/cm or mN/m) |
No data available |
|
Vapour pressure (kPa) |
No data available |
Volatile Component (%vol) |
No data available |
|
Solubility (g/L) |
Soluble in water |
Gas group |
No data available |
|
Vapour density (Air = 1) |
No data available |
pH as a solution (1%) |
No data available |
|
VOC g/L |
No data available |
|
|
SECTION 10 STABILITY AND REACTIVITY
|
Reactivity |
Contact with incompatible substances may cause decomposition or other chemical reactions. |
|
Chemical stability |
Stable under proper operation and storage conditions. |
|
Possibility of hazardous reactions |
No information available |
|
Conditions to avoid |
Incompatible materials, heat, flame and spark. |
|
Incompatible materials |
No information available |
|
Hazardous decomposition products |
Under normal conditions of storage and use, hazardous decomposition products should not be produced. |
SECTION 11 TOXICOLOGICAL INFORMATION
Acute toxicity
|
Acute toxicity |
No information available |
Carcinogenicity
|
Component |
Cas No. |
IARC |
NTP |
|
ATMP |
6419-19-8 |
Not Listed |
Not Listed |
|
EDTMPS |
22036-77-7 |
Not Listed |
Not Listed |
Other
|
Skin corrosion/irritation |
Based on available data, the classification criteria are not met |
|
Serious eye damage/irritation |
Causes serious eye damage (Category 2A) |
|
Skin sensitization |
May cause an allergic skin reaction (Category 1) |
|
Respiratory sensitization |
Based on available data, the classification criteria are not met |
|
Reproductive toxicity |
Based on available data, the classification criteria are not met |
|
STOT-single exposure |
Based on available data, the classification criteria are not met |
|
STOT-repeated exposure |
Based on available data, the classification criteria are not met |
|
Aspiration hazard |
Based on available data, the classification criteria are not met |
|
Germ cell mutagenicity |
Based on available data, the classification criteria are not met |
|
Reproductive toxicity(additional) |
Based on available data, the classification criteria are not met |
|
Acute aquatic toxicity |
No data available |
|
Chronic aquatic toxicity |
No data available |
|
Persistence and degradability |
No data available |
|
Bioaccumulative potential |
No data available |
|
Mobility in soil |
No data available |
|
Results of PBT and vPvB assessment |
No data available |
|
Other information |
No data available |
|
Waste chemicals |
Before disposal should refer to the relevant national and local laws and regulation. |
|
Contaminated packaging |
Containers may still present chemical hazard when empty. Keep away from hot and ignition source of fire. |
|
Disposal recommendations |
Refer to section 13.1and 13.2. |
|
Transporting Label |
NOT APPLICABLE |
|
Land transport (UN-ADR) |
NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS |
|
Air transport (ICAO-IATA/DGR) |
NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS |
|
Sea transport (IMDG-Code/GVSee) |
NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS |
International chemical inventory
|
Component |
EINECS |
TSCA |
DSL |
IECSC |
NZIoC |
PICCS |
KECI |
AICS |
ENCS |
|
ATMP |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
|
Water |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
|
EDTMPS |
√ |
× |
× |
√ |
√ |
√ |
√ |
√ |
× |
【EINECS】 European Inventory of Existing Commercial Chemical Substances
【TSCA】 United States Toxic Substances Control Act Inventory
【DSL】 Canadian Domestic Substances List
【IECSC】 China Inventory of Existing Chemical Substances
【NZIoC】 New Zealand Inventory of Chemicals
【PICCS】 Philippines Inventory of Chemicals and Chemical Substances
【KECI】Existing and Evaluated Chemical Substances
【AICS】Australia Inventory of Chemical Substances
【ENCS】Existing And New Chemical Substances
Note
“√” Indicates that the substance included in the regulations “×” That no data or included in the regulations
REVISED INFORMATION: Significant changes to regulatory or health information for this revision is indicated by a bar in the left-hand margin of the SDS.
Reference
[1]IPCS:The International Chemical Safety Cards (ICSC) ,website: http://www.ilo.org/dyn/icsc/showcard.home.
[2]IARC，website: http://www.iarc.fr/.
[3]OECD: The Global Portal to Information on Chemical Substances, website:
http://www.echemportal.org/echemportal/index?pageID=0&request_locale=en.
[4]CAMEO Chemicals, website: http://cameochemicals.noaa.gov/search/simple.
[5]NLM:ChemIDplus, website: http://chem.sis.nlm.nih.gov/chemidplus/chemidlite.jsp.
[6]EPA: Integrated Risk Information System, website: http://cfpub.epa.gov/iris/.
[7]U.S. Department of Transportation:ERG, website: http://www.phmsa.dot.gov/hazmat/library/erg.
[8]Germany GESTIS-database on hazard substance, website: http://gestis-en.itrust.de/.
Abbreviations and acronyms
|
CAS –Chemical Abstracts Service |
CMR - Carcinogens, mutagens or substances toxic to reproduction |
|
PC-STEL- Short term exposure limit |
PC-TWA - Time Weighted Average |
|
DNEL - Derived No Effect Level |
IARC - International Agency for Research on Cancer |
|
RPE - Respiratory Protective Equipment |
PNEC –Predicted No Effect Concentration |
|
LC50 - Lethal Concentration 50% |
LD50 - Lethal Dose 50% |
|
NOEC -No Observed Effect Concentration |
EC50 - Effective Concentration 50% |
|
PBT - Persistent, Bioaccumulative, Toxic |
POW - Partition coefficient Octanol:Water |
|
BCF - Bioconcentration factor (BCF) |
vPvB - very Persistent, very Bioaccumulative |
|
IMDG-International Maritime Dangerous Goods |
ICAO/IATA-International Civil Aviation Organization/International Air Transportation Association |
|
UN-The United Nations |
ACGIH-American Conference of Governmental Industrial Hygienists |
|
NFPA-National Fire Protection Association |
OECD-Organization for Economic Co-operation and Development
|
Disclaimer：
|
End of SDS |
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. For additional copies of an SDS reach out to your local representative and request access.
